(1. 中南大學 化學化工學院，長沙 410083；
2. 湖南工程學院 機械工程學院，湘潭 411101)
摘 要: 在常壓下研究碳熱還原氧化銦的動力學。結果表明:增大碳與含銦渣的質量比或提高反應溫度，銦還原率增大。當反應溫度為1523 K，碳與含銦渣質量比為0.5、反應時間為60 min時，含銦渣銦的還原揮發率達到 85.21%；在常壓下，碳與含銦渣質量比達到0.5，含銦渣平均粒度是80 μm，石墨顆粒平均度約為30 μm，反應溫度在1373~ 1523 K區間內，碳熱還原含銦渣的還原揮發速率由界面化學反應所控制，其表觀活化能為168.67 kJ/mol。
關鍵字: 碳熱還原；含銦渣；動力學；銦；熔池熔煉
（1. College of Chemistry and Chemical Engineering, Central South University, Changsha 410083, China;
2. Department of Mechanical Engineering, Hunan Institute of Engineering, Xiangtan 411101, China）
Abstract:The kinetics of atmospheric carbothermic reduction of indium oxide slag was investigated. The results indicate that the reduction volatilization ratio of indium increases with the quality ratio of mass ratio of C and slag containing In or the reaction temperature increasing, the highest indium reduction 85.21% was realized under the condition of the mass ratio of C and slag containing In of 0.5 at 1523 K after 60 min. The interface reaction is the controlling step of the overall reduction process and the activation energy is estimated to be 168.67 kJ/mol when the mass ratio of C and slag containing In is o.5, the average size of slag is 80 μm, the average size of graphite is 30 μm and the reaction temperature is from 1273 to 1523 K.
Key words: carbon thermoreduction; indium oxide slag; kinetics; indium; bath smelting
