(中南工業大學有色冶金系，長沙 410083
中州鋁廠，焦作 454174)
摘 要: 對加入石灰后的高苛性比鋁酸鈉溶液中氧化鋁的回收進行了研究。熱力學計算結果表明，氧化鈣較氫氧化鈣更容易使鋁酸鈉溶液中的鋁酸根離子轉化為水合鋁 酸鈣，使鋁酸鈉溶液的平衡苛性比能達到很高的值；水合鋁酸鈣隨著溫度的升高，穩定性降低，因而能在拜爾法高溫溶出過程中分解以代替石灰，并回收其中的氧化鋁。實驗結果表明，影響水合鋁酸鈣形成因素的大小順序為：溫度≈堿濃度＞CaO/Al2O3＞時間。
關鍵字: 鋁酸鈉溶液 氧化鈣 水合鋁酸鈣
（Department of Nonferrous Metallurgy, Central South University of Technology,Changsha 410083, P. R. China
1 Zhongzhou Alumina Factory, Jiaozuo 454174, P. R. China）
Abstract:The recovery of alumina in the high mole ratio (αk) aluminate solution was studied. The thermodynamic calculation results i ndicated that the formation of calcium aluminate hydrate from aluminate solution with CaO is easier than that with Ca(OH)2, and the value of αk is great at low temperature ; the temperature rise leads to the reduction of stability of calcium aluminate hydrate in the aluminate solution, and it can be decomposed at high temperature , which can both substitute for Ca(OH)2 and recover alumina in the process of Bayer. The order of affecting the formation of calcium aluminate hydrate is as follows: temperature≈concentration of caustic soda＞CaO/Al2O3 (mole ratio)＞time.
Key words: aluminate solution calcium oxide calcium aluminate hydrate
