( 1. 東北大學 材料電磁過程研究教育部重點實驗室，沈陽 110004;
2. 東北大學 理學院， 沈陽 110004)
摘 要: 采用Gleeble-1500D熱模擬試驗機、 差熱分析儀和光學顯微鏡等對低頻電磁鑄造AZ41鎂合金鑄錠熱壓縮流變特征及微觀組織進行研究。 結果表明： AZ41鎂合金鑄錠熱壓縮變形存在明顯的動態回復和動態再結晶特征； 當溫度為453～523 K時， 以動態回復為主； 當溫度為593～723 K時， 以動態再結晶為主要機制； 當溫度為593 K， 應變速率為1.0 s-1時， 形變激活能最低， 流變過程最穩定， 中心和邊緣部位的晶粒得到明顯細化。 在變形期間， Mg17Al12相的破碎和溶解促進動態再結晶顯著發生。
關鍵字: AZ41鎂合金； Mg17Al12 相； 低頻電磁鑄造； 動態再結晶
ZHANG Cai-bei2
（ 1. Key Laboratory of Electromagnetic Processing of Materials,
Ministry of Education, Northeastern University,
Shenyang 110004, China;
2. College of Science, Northeastern University,
Shenyang 110004, China）
Abstract: The characteristics of thermal compressing flow and microstructure of AZ41 magnesium alloy cast by low frequency electrical magnetic field (LFEMC) were studied through thermal simulation tester Gleeble-1500D.The results show that there exist obviously dynamic recovery and dynamic recrystallization (DRX) during thermal compression of the LFEMC AZ41 magnesium alloy. The dynamic recovery is prominent character at 453-523 K, but DRX is prominent behavior at 593-723 K. The flow process is the most stable and the microstructures at the center and the edge of specimens are markedly refined by DRX at the temperature of 593 K and the strain rate of 1.0 s-1. The crash and dissolution of Mg17Al12 phase accelerate DRX during deforming.
Key words: AZ41 magnesium alloy; Mg17Al12 phase; low frequency electrical magnetic field; dynamic recrystallization
